Product ID:DAP-ON (OIL BASED) CAULK
MSDS Date:01/01/1996
FSC:8030
NIIN:00-243-0956
Status Code:A
MSDS Number: CKKHC

Emergency Phone: 800-543-3840 800-535-5053

Info Phone: 800-513-3810

Preparer: EISENHARD

Cage: 90300

Telephone: 513-253-7154/800-543-3840

Cage: 90300

MINERAL SPIRITS

CAS: 64475-85-0

RTECS: PY8240000

Fraction By Weight: 1-5%

OSHA PEL 100 PPM TWA

ACGIH TLV: 100 PPM TWA

REMAINING INGREDIENTS ARE NOT REGULATED BY OSHA AND ARE

Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATE EYES, SKIN, NOSE, AND
UPPER RESP TRACT. HARMFUL IF INHALED. HARMFUL OR FATAL IF
SWALLOWED. IF INGESTED, MAY CAUSE VOMITING, DIARRHEA, & DEPRESSED
RESPIRATION. INHALATION MAY EFFECT BRA IN OR NERVOUS SYSTEM,
CAUSING DIZZINESS, HEADACHE, NAUSEA. CHRONIC: REPORTS PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE TO OVEREXPOSURE TO SOLVENTS.
Medical Cond Aggravated by Exposure:NONE KNOWN

First Aid:EYE:FLUSH WITH WATER FOR 15 MINUTES. CALL PHYSICIAN IMMED.
SKIN: WASH W/ SOAP & WATER. INHAL: REMOVE TO FRESH AIR. CONTACT DR.
IMMED. INGEST: DO NOT INDUCE VOMITING. CONTACT DR OR REGIONAL
CONTROL CEN TER IMMED.

Flash Point Method:TCC
Flash Point:=52.2C, 126.F
Lower Limits:NOT ESTABLIS
Upper Limits:NOT ESTABLIS
Extinguishing Media:CO*2,FOAM,DRY CHEMICAL
Fire Fighting Procedures:FULL PROTECTIVE EQUIP INCLUDING SCBA TO
PROTECT FROM COMBUSTION PRODUCTS. USE WATER SPRAY TO COOL EXPOSED
SURFACES.
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE IF EXPOSED TO
EXTREME HEAT. ELIMINATE SOURCES OF IGNITION: HEAT, ELECTRICAL
EQUIPMENT, SPARKS, FLAMES. DO NOT PUT INTO CONTACT W/ OXIDIZING OR
CAUSTIC MATERIALS.

Spill Release Procedures:USE ABSORBENT MATERIAL, OR SCRAPE UP DRIED
MATERIAL & PLACE INTO CONTAINERS.

Handling and Storage Precautions:STORE AWAYFROM CAUSTICS & OXIDIZERS.
KEEP OUT OF REACH OF CHILDREN. KEEP CONTAINERS AWAY FROM EXCESSIVE
HEAT & FREEZING. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE.
INTENTIONAL MISUSE BY DELIBERA TELY CONCENTRATING & INHALING VAPORS
MAY BE HARMFUL OR FATAL.

Respiratory Protection:IF 8 HOUR EXPOSURE LIMIT/VALUE IS EXCEEDED FOR
ANY COMPONENT, USE NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN. CONSULT OSHA STANDARDS.
Ventilation:SUFFICIENT MECHANICAL VENTILATION. LOCAL OR GENERAL EXHAUST
(TO KEEP BELOW PEL/TLV).VAPORS >AIR & COLLECT IN LOW AREAS. CHECK
ALL LOW AREAS(BASEMNTS,SUMPS,ETC)
Protective Gloves:SOLVENT IMPERVIOUS GLOVES
Eye Protection:GOGGLES & SAFETY GLASSES.
Other Protective Equipment:PROVIDE EYE WASH & SOLVENT IMPERVIOUS APRON
IF BODY CONTACT W/ PRODUCT MAY OCCUR. BARRIOR CREAMS MAY BE USED.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health

Boiling Pt:=162.8C, 325.F
Vapor Pres:2 MM HG @ 20 C
Vapor Density:>1 AIR =1
Spec Gravity:1.9 WATER=1
VOC Pounds/Gallon:105
Viscosity:0.3 "MAX @ 122 F 10 MIN
Evaporation Rate & Reference:<1 N-BU AC=1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAGUE PASTE W/ A MILD ODOR.
Percent Volatiles by Volume:14

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS AND CAUSTICS.
Stability Condition to Avoid:EXCESSIVE HEAT AND FREEZING.
Hazardous Decomposition Products:NORMAL COMBUSTION PRODUCTS, I.E. COX,
NOX

Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL,STATE AND FEDERAL
REGULATIONS. DISCARDED MATERIALS SHOULD BE INCINERATED AT A
PERMITTED FACILITY. DO NOT REUSE EMMPTY CONTAINER.

Transport Information:APPLICABLE REGULATIONS: 49 CFR

SARA Title III Information:LL INGREDIENTS IN THIS PRODUCT ARE ON THE
TSCA INVENTORY LIST.
State Regulatory Information:INGREDIENTS PER THE NJ RIGHT TO KNOW ACT:
CALCIUM CARBONATE, 1317-65-3, HYDROUS MAGNESIUM SILICATE
14807-96-6, MINERAL SPIRITS 8052-51-3, LINSEED OIL 67746-08-1,
VEGETABLE OIL 68152-81-1, AND MINERAL SPIRITS 8032-32-4. THIS
PRODUCT IS DOT: NOT REGULATED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.